20th death from faulty Takata air bags reported by Honda

Takata recall

A faulty Takata air bag inflator has killed another person, this time in Baton Rouge, Louisiana, Honda said Tuesday night.

The unidentified person is the 20th death worldwide attributed to the faulty inflators, which can explode with too much force and hurl shrapnel into car and truck cabins.

The person died in a July 10 crash of a 2004 Honda Civic. Officials from the automaker and the National Highway Traffic Safety Administration inspected the car Tuesday and confirmed that the driver's air bag inflator blew apart and caused the death, Honda spokesman Marcos Frommer said.

Honda learned about the death only recently, and jointly inspected the car with government officials on Tuesday, he said. Honda did not release the person's name or age.

Takata uses the chemical ammonium nitrate to create a small explosion that inflates air bags in a crash. But the chemical can deteriorate when exposed to high temperatures and humidity and burn too fast, blowing apart a metal canister.

The problem has touched off the largest series of automotive recalls in U.S. history — involving 42 million vehicles and as many as 69 million inflators — and forced Takata of Japan into bankruptcy protection. More than 100 million inflators have been recalled worldwide.

Honda says in a statement that the car's air bag apparently was salvaged from another vehicle, a 2002 Civic. The owners of the 2004 Civic also had been sent multiple recall notices to replace the original inflator starting in June 2014, but the repair had not been made, Honda said.

Takata pleads guilty to U.S. fraud charges over defective airbags

The company said it is cooperating with the government as it investigates the matter.

Messages were left Tuesday night seeking comment from a NHTSA spokeswoman and the Baton Rouge police.

The death comes about one month after a report on the Takata recalls shows that automakers have replaced only 43 percent of the faulty parts even though recalls have been under way for more than 15 years.

The report, issued by an independent monitor who is keeping tabs on the recalls, also shows that auto companies are only about halfway toward a Dec. 31 goal of 100 percent replacement of older and more dangerous inflators.

The slow completion rate comes even though NHTSA coordinated the recalls and phased them in two years ago. Before that, the automakers were obtaining parts and distributing them on their own. Normally automakers fix 75 percent of vehicles within 18 months after the recall is announced.

Completion rates vary wildly by automaker, according to NHTSA. Tesla was best at 78.6 percent, followed by Honda at 64.8 percent. Mercedes-Benz was the worst at 2.3 percent.

Honda, which was Takata's largest customer, has been going door-to-door trying to persuade owners to get their cars repaired. The company also is using Facebook in an effort to track down owners.

Frommer said the inflator from the 2002 Civic that was placed in the 2004 Civic in Baton Rouge likely was one of the most dangerous types made by Takata. Such inflators are in 2001-2003 Hondas. Tests have shown they have a 50 percent chance of blowing apart in a crash.

Owners can check to see if their cars have been recalled by going to https://www.nhtsa.gov/recalls and keying in their 17-digit vehicle identification number.

The deaths have occurred since May of 2009:

— May 27, 2009: Ashley Parham, 18, of Midwest City, Oklahoma, 2001 Honda Accord

— Dec. 24, 2009: Gurjit Rathore, 33, of Richmond, Virginia, 2001 Honda Accord

— Sept. 13, 2013: Hai Ming Xu, of Alhambra, California, 2002 Acura TL

— July 27, 2014: Law Suk Leh of Sibu, Malaysia, 2003 Honda City

— Sept. 7, 2014: Jewel Brangman, 26, of California, 2001 Honda Civic

— Sept. 29, 2014: Hien Thi Tran, 51, of Orlando, Florida, 2001 Honda Accord

— Jan. 18, 2015: Carlos Solis, 35, of Spring, Texas, 2002 Honda Accord

— April 15, 2015: Kylan Langlinais, 23, of Lafayette, Louisiana, 2005 Honda Accord

— July 22, 2015: Unidentified 13-year-old boy, Mercer County, Pennsylvania, 2001 Honda Accord

— Dec. 22, 2015: Joel Knight, 52, of Kershaw, South Carolina, 2006 Ford Ranger

— March 31, 2016: Huma Hanif, 17, of Fort Bend County, Texas, 2002 Honda Civic

— April 16, 2016: Unidentified person, Sabah State, Malaysia, 2006 Honda City. Inflator ruptured, no death cause determined.

— May 1, 2016: Unidentified person, Malaysia, 2003 Honda City. Inflator ruptured, no death cause determined.

— June, 2016: Unidentified person in Malaysia. Inflator ruptured, no death cause determined.

—June 19, 2016: Ramon Kuffo, 81, Hialeah, Florida. Inflator ruptured while he was repairing interior of car.

— Sept. 24, 2016: Unidentified driver, Johor State, Malaysia, 2009 Honda City. Inflator ruptured, no death cause determined.

— Sept. 30, 2016: Delia Robles, 50, of Corona, California, 2001 Honda Civic.

— July 10, 2017: Unidentified person in Baton Rouge, Louisiana, 2004 Honda Civic.

— July 13, 2017: Unidentified 58-year-old man in suburban Sydney, 2007 Honda CR-V.

— July 19, 2017: Nichol Lynn Barker, 34, of Holiday, Florida, 2002 Honda Accord.